815501
20
Verklein
Vergroot
Pagina terug
1/30
Pagina verder
Vermont Castings • Encore Model 2040-CAT-C Owner’s Manual_R14 • 2019 - ___ • 12/23 208390-204C
When to Suspect a Combustor Problem
The best way to evaluate the performance of your appliance’s
combustor is to observe the amount of smoke leaving the
chimney—bothwhenthecombustorhas“lighted-o󰀨”and
whenithasnot.Followthesesteps:
• Witharegoingandthecombustorproperlyactivated,with
the damper closed to route smoke through it as described
in the Operation Section, go outside and observe the
smoke leaving the chimney.
Then, open the stove damper and once again check the
smoke leaving the chimney.
You should see signicantly more smoke when thestove
damperis open and exhaust does not pass through the
combustor.However,becarefulnottoconfusesmokewith
steamfromwetwood.Steamdissipatesintheairquickly;
smoke does not.
Ifthistestindicatesaproblem,considerotherpossiblefactors
as well, such as the weather or a change in the quality of
yourfuel.Inwarmweather,draftisweakerthanitisincolder
winterweather,andrescanburnsluggishly.Small,hotres
are a good solution under these conditions.
Burning“green”(insu󰀩cientlyseasoned)woodwillresultin
poorer performance than burning properly seasoned fuel.
Reloadingwith green wood can also thermal shock the
catalyst, resulting in cracking, or the eventual fallout, of the
ceramichoneycombsubstrate.Youmayhavetorunyour
stovehotter(moreair)toachieveacceptableperformance
using green or wet wood.
Also, consider any changes in your operating routine.
Onceyouhaveruledoutanyotherpossiblecausesfora
decline in performance, inspect and clean the combustor if
necessary.Besuretoprotectanysurfaceyouuseforsetting
the stove parts aside.
Also, consider any changes in your operating routine.
Onceyouhaveruledoutanyotherpossiblecausesfora
decline in performance, inspect and clean the combustor if
necessary.Besuretoprotectanysurfaceyouuseforsetting
the stove parts aside.
Inspecting the Combustor
Removeaccessdoorandinnerrebrick.Removethecatalytic
combustorbyliftingupandpullingtowardsyou,Figure3.7.
NOTE
Burning“green”(insu󰀩cientlyseasoned)woodwillresult
in poorer performance than burning properly seasoned
fuel.Reloadingwithgreenwoodcanalsothermalshock
the catalyst, resulting in cracking, or the eventual fallout, of
themetalhoneycombsubstrate.Youmayhavetorunyour
stovehotter(moreair)toachieveacceptableperformance
using green or wet wood.
ST1180
catalyst access
Catalyst
Access Door
InnerFireback
Figure 3.7-Inspectthecatalyticcombustor.
To assure a long life for the combustor, it is recommended
to service the combustor on a regular basis based on the
amountofuse.Thisproceduretakesaboutve(5)minutes
andrequiresno tools except for a vacuum if cleaning is
necessary.
Cleaning the Combustor
1. Check the combustors honeycomb-like element for a
buildupofyash.Ifanyisevident,takethecombustor
outside and clean it by blowing air gently through it. Do
notpushanythingthroughthehoneycomb;donotuse
compressedairtoclearthepassages.Suchabrasioncan
scrapethethincoatingofplatinum(thecatalyst)o󰀨the
ceramic base, shortening the catalyst’s life and reducing
itse󰀨ectiveness.
2.Inspecttheelementfordamageordegradation.Although
small hairline cracks will not a󰀨ect performance, the
element should be essentially intact. If the element is
broken in pieces or has sections missing, it should be
replaced. Call your local Vermont CastingsAuthorized
Dealer for a replacement element.
3.Iftheelementisingoodconditionandclean,re-installit
inthestoveandreplacetherefractoryinnerrebackand
access door.
Operate the stove in your usual manner for two weeks,
inspecting the chimney and the chimney connector frequently
during this period.
If creosote does not build up as fast, it is likely that the
performance change was caused by y ash deposits on
thecatalyticelement.However,continuetheinspectionsof
the chimney system for a few weeks to ensure that proper
performance continues.
Ifyoucontinuetonda signicantcreosotebuildup or if
you continue to see excessive smoke from the chimney,
the catalytic element will need to be replaced. Contact your
nearestVermontCastings’AuthorizedDealerforinformation
about a replacement element.
NOTE: Use only the replacement catalyst supplied by a
VermontCastingsdealer.
20

Hulp nodig? Stel uw vraag in het forum

Spelregels

Misbruik melden

Gebruikershandleiding.com neemt misbruik van zijn services uitermate serieus. U kunt hieronder aangeven waarom deze vraag ongepast is. Wij controleren de vraag en zonodig wordt deze verwijderd.

Product:

Bijvoorbeeld antisemitische inhoud, racistische inhoud, of materiaal dat gewelddadige fysieke handelingen tot gevolg kan hebben.

Bijvoorbeeld een creditcardnummer, een persoonlijk identificatienummer, of een geheim adres. E-mailadressen en volledige namen worden niet als privégegevens beschouwd.

Spelregels forum

Om tot zinvolle vragen te komen hanteren wij de volgende spelregels:

Belangrijk! Als er een antwoord wordt gegeven op uw vraag, dan is het voor de gever van het antwoord nuttig om te weten als u er wel (of niet) mee geholpen bent! Wij vragen u dus ook te reageren op een antwoord.

Belangrijk! Antwoorden worden ook per e-mail naar abonnees gestuurd. Laat uw emailadres achter op deze site, zodat u op de hoogte blijft. U krijgt dan ook andere vragen en antwoorden te zien.

Abonneren

Abonneer u voor het ontvangen van emails voor uw Vermont Castings Encore bij:


U ontvangt een email met instructies om u voor één of beide opties in te schrijven.


Ontvang uw handleiding per email

Vul uw emailadres in en ontvang de handleiding van Vermont Castings Encore in de taal/talen: Engels als bijlage per email.

De handleiding is 4.61 mb groot.

 

U ontvangt de handleiding per email binnen enkele minuten. Als u geen email heeft ontvangen, dan heeft u waarschijnlijk een verkeerd emailadres ingevuld of is uw mailbox te vol. Daarnaast kan het zijn dat uw internetprovider een maximum heeft aan de grootte per email. Omdat hier een handleiding wordt meegestuurd, kan het voorkomen dat de email groter is dan toegestaan bij uw provider.

Stel vragen via chat aan uw handleiding

Stel uw vraag over deze PDF

loading

Andere handleiding(en) van Vermont Castings Encore

Vermont Castings Encore Gebruiksaanwijzing - Français - 46 pagina's


Uw handleiding is per email verstuurd. Controleer uw email

Als u niet binnen een kwartier uw email met handleiding ontvangen heeft, kan het zijn dat u een verkeerd emailadres heeft ingevuld of dat uw emailprovider een maximum grootte per email heeft ingesteld die kleiner is dan de grootte van de handleiding.

Er is een email naar u verstuurd om uw inschrijving definitief te maken.

Controleer uw email en volg de aanwijzingen op om uw inschrijving definitief te maken

U heeft geen emailadres opgegeven

Als u de handleiding per email wilt ontvangen, vul dan een geldig emailadres in.

Uw vraag is op deze pagina toegevoegd

Wilt u een email ontvangen bij een antwoord en/of nieuwe vragen? Vul dan hier uw emailadres in.



Info