802492
8
Verklein
Vergroot
Pagina terug
1/12
Pagina verder
Heater operation
The heater can be operated according to the installed equipment using the Valeo control
elements switch or pre-selection timer. All information about the Valeo pre-selection timer
SC Preheater can be found on the Valeo website.
In addition, control via the vehicle's own climate control is possible.
Before you switch on the heater set the vehicle's heating system to “Warm”.
During all active operating phases of the heater, all electric components, the operating
voltage and functional irregularities are monitored and recorded.
In the event of faults always first check the following:
Is the fuel supply ok?
Is a sufficient amount of fuel in the tank?
Are the fuses ok?
Are the electrical connections and cables in order?
Are the combustion- and exhaust air ways free of obstructions?
A malfunction causes the heater to terminate its operation by a fault shut-off and to go into
the fault lock-out mode to prevent the heater from an automatic combustion restart. At the
same time the operation indicator begins to flash with a specific code (see below).
The fault lock-out occurs:
low voltage during a defined period
if combustion was not established during start-up
if the flame extinguishes during operation
extrinsic light
if the control device itself has failed or peripheral components are defective
Malfunctions
Liability claims
Failure to follow the installation instructions and the notes contained therein will lead to all
liability being refused by Valeo. The same applies if repairs are carried out incorrectly or
with the use of parts other than genuine spare parts.
This will result in the expiry of the ECE type approval of the heater and thus the general
operating permit.
Liability claims can only be made if the claimant has verifiably considered all the servicing
and safety instructions.
Operating and
service instructions
Flash code
The kind of malfunction is indicated from the operating indication light through a flash code
or if the pre-selection timer is used in the display (operation display). The flash code is
immediately generated after detection of the malfunction and will be kept until the heater
is freed.
The flash code comprises of a burst (sequence) of 5 short flashes depicting the break and a
defined number of long pulses corresponding to the malfunction number, which are to be
counted. After that the cycle starts with 5 short flashes again and so on.
The meaning of the number of long pulses is shown in the table below.
Table: Flash codes
No. of
long pulses Description of malfunction
0 Control device defective
1 No start within the safety time
2 Flame interruption, restart failed
3 Low voltage / overvoltage
4 Extrinsic light before starting or within the purge cycle
5 Flame guard defective
6 Temperature sensor / overheat protection defective
7 Solenoid valve defective
8 Combustion air fan motor / nozzle block pre-heater defective
9 Circulating pump defective
10 Overheat protection has been triggered
11 Electronic ignition unit defective
12 Heater lock-out activated
Variants to reset the heater after a fault lock-out:
1. Switch off the heater and then turn it on again
2. Reset the control device, e.g. through disconnecting it from the power supply
3. Off and On switching“ via the S-Bus diagnostic interface
4. Erase the data in the fault memory by means of the diagnostic tool.
Additional to the fault lock-out a heater lock-out occurs if safety related components are
affected. The fault code 12 will be displayed (see para. Flash code“).
If a heater lock-out has occurred, the heater must be maintained and released by Valeo
trained personnel.
Thermo E+
120/200/320
8

Hulp nodig? Stel uw vraag in het forum

Spelregels

Misbruik melden

Gebruikershandleiding.com neemt misbruik van zijn services uitermate serieus. U kunt hieronder aangeven waarom deze vraag ongepast is. Wij controleren de vraag en zonodig wordt deze verwijderd.

Product:

Bijvoorbeeld antisemitische inhoud, racistische inhoud, of materiaal dat gewelddadige fysieke handelingen tot gevolg kan hebben.

Bijvoorbeeld een creditcardnummer, een persoonlijk identificatienummer, of een geheim adres. E-mailadressen en volledige namen worden niet als privégegevens beschouwd.

Spelregels forum

Om tot zinvolle vragen te komen hanteren wij de volgende spelregels:

Belangrijk! Als er een antwoord wordt gegeven op uw vraag, dan is het voor de gever van het antwoord nuttig om te weten als u er wel (of niet) mee geholpen bent! Wij vragen u dus ook te reageren op een antwoord.

Belangrijk! Antwoorden worden ook per e-mail naar abonnees gestuurd. Laat uw emailadres achter op deze site, zodat u op de hoogte blijft. U krijgt dan ook andere vragen en antwoorden te zien.

Abonneren

Abonneer u voor het ontvangen van emails voor uw Valeo Thermo E plus bij:


U ontvangt een email met instructies om u voor één of beide opties in te schrijven.


Ontvang uw handleiding per email

Vul uw emailadres in en ontvang de handleiding van Valeo Thermo E plus in de taal/talen: Duits, Engels als bijlage per email.

De handleiding is 1.19 mb groot.

 

U ontvangt de handleiding per email binnen enkele minuten. Als u geen email heeft ontvangen, dan heeft u waarschijnlijk een verkeerd emailadres ingevuld of is uw mailbox te vol. Daarnaast kan het zijn dat uw internetprovider een maximum heeft aan de grootte per email. Omdat hier een handleiding wordt meegestuurd, kan het voorkomen dat de email groter is dan toegestaan bij uw provider.

Stel vragen via chat aan uw handleiding

Stel uw vraag over deze PDF

loading

Uw handleiding is per email verstuurd. Controleer uw email

Als u niet binnen een kwartier uw email met handleiding ontvangen heeft, kan het zijn dat u een verkeerd emailadres heeft ingevuld of dat uw emailprovider een maximum grootte per email heeft ingesteld die kleiner is dan de grootte van de handleiding.

Er is een email naar u verstuurd om uw inschrijving definitief te maken.

Controleer uw email en volg de aanwijzingen op om uw inschrijving definitief te maken

U heeft geen emailadres opgegeven

Als u de handleiding per email wilt ontvangen, vul dan een geldig emailadres in.

Uw vraag is op deze pagina toegevoegd

Wilt u een email ontvangen bij een antwoord en/of nieuwe vragen? Vul dan hier uw emailadres in.



Info