480910
1
Verklein
Vergroot
Pagina terug
1/13
Pagina verder
POW60481 EN
Copyright © 2014 VARO P a g e | 1 www.varo.com
1 APPLICATION .................................................................................. 3
2 OVERVIEW COMPONENTS (FIG. A).............................................. 3
3 PACKAGE CONTENT LIST ............................................................. 3
4 SYMBOLS ........................................................................................ 4
5 SAFETY WARNINGS ....................................................................... 4
5.1 General safety warnings ......................................................................................... 4
5.2 What not to do ......................................................................................................... 5
5.3 Danger of fire and burn injuries. ............................................................................ 6
5.4 Observance while operating ................................................................................... 6
6 ASSEMBLY ...................................................................................... 7
6.1 Fitting the plastic guard .......................................................................................... 7
6.2 Fitting the curvy drive shaft ................................................................................... 7
6.3 Fitting the handle .................................................................................................... 7
6.3.1 If you use the "OPEN" type handle bar, by the following method: .............................. 7
7 BEFORE STARTING WORK ........................................................... 8
7.1 Fuelling .................................................................................................................... 8
8 OPERATION ..................................................................................... 8
8.1 Starting the Grass Trimmer .................................................................................... 8
8.2 Stopping the grass trimmer.................................................................................... 9
8.3 Running in the engine............................................................................................. 9
8.4 Use of the Grass Trimmer ...................................................................................... 9
9 CLEANING AND MAINTENANCE ................................................. 10
9.1 Air filter .................................................................................................................. 10
9.2 Fuel filter ................................................................................................................ 10
9.3 Checking the Spark Plug ...................................................................................... 10
9.4 Storage and maintenance after use ..................................................................... 10
10 TROUBLESHOOTING ................................................................... 11
10.1 Power loss or sudden stopping of the engine .................................................... 11
10.2 Bad quality cut ...................................................................................................... 11
11 TECHNICAL DATA ........................................................................ 11
POW60481 EN
Copyright © 2014 VARO P a g e | 2 www.varo.com
12 NOISE ............................................................................................. 11
13 WARRANTY ................................................................................... 11
14 ENVIRONMENT ............................................................................. 12
15 DECLARATION OF CONFORMITY .............................................. 13
POW60481 EN
Copyright © 2014 VARO P a g e | 3 www.varo.com
GRASS TRIMMER 29.7cc
POW60481
1 APPLICATION
The machine unit is designed for trimming grasses; do not use it for any other purpose. De
device cannot be used for other purposes. The manufacturer will no longer be liable when the
device is used for a purpose other than what is intended or if it is modified. Please take the
safety guidelines, the assembly and operation manual, as well as the general conditions for
the prevention of accidents into account.
WARNING! Read this manual and general safety instructions carefully
before using the appliance, for your own safety. Your power tool should
only be passed on together with these instructions.
2 OVERVIEW COMPONENTS (FIG. A)
1. Line cutting head
2. Plastic guard
3. Drive shaft ASM
4. Iron joint shaft cover
5. Secondary handle
6. Recoil starter
7. Fuel tank cover
8. Air cleaner
9. Choke lever
10. Primer bulb
11. Operating handle
12. Throttle button
13. Safety lever
14. Ignition switch
3 PACKAGE CONTENT LIST
Remove all packing materials.
Remove remaining packaging and transit supports (if existing).
Check the completeness of the packing content.
Check the appliance, the power cord, the power plug and all accessories for transportation
damages.
Keep the packaging materials as far as possible till the end of the warranty period.
Dispose it into your local waste disposal system afterwards.
WARNING Packing materials are no toys! Children must not play with
plastic bags! Danger of suffocation!
1 x Grass trimmer 29.7cc
1 x Manual
1 x Cutting head
1 x 'spool tighten key'
1 x open ended spanner
1 x oil/fuel mixing tank
1 x Plastic guard
1 x Shoulder strap
When parts are missing or damaged, please contact your dealer.
POW60481 EN
Copyright © 2014 VARO P a g e | 4 www.varo.com
4 SYMBOLS
In this manual and/or on the machine the following symbols are used:
Read the manual before
using the machine
Wear good and sturdy gloves!
Denotes risk of personal
injury or damage to the tool.
Wear approved hearing
protection and safety glasses
In accordance with essential
requirements of the
European directive(s)
Wear sturdy shoes with
antiskid soles !
Keep a minimum distance of
15m between the machine
and third parties during use
Watch out for particles
generated by the cutting
installation.
Beware of thrown objects hit
by cutting attachment
Beware of foot injury by cutting
attachment.
5 SAFETY WARNINGS
5.1 General safety warnings
This power unit can be dangerous!
When using the unit, basic safety precaution, including the following, should always be
followed to reduce the risk or serious personal injury and damage to the unit.
Read all these instruction before operating this production and save these instructions. Be
thoroughly familiar with the controls and the proper use of the unit. Restrict the use of this
unit to persons who do not read, understand, and follow unit, manual instruction and
warnings.
Never allow children to operate this unit.
WARNING Keep children, bystanders, and animals 50 feet (15 meters) away.
If approached stop the unit immediately.
WARNING Sound power level emitted by the machinery is 105Db when
trimming with the device.
When sets run, please use the earplug.
Wear clothes fitting, though work clothing that will provide protection, such as long slacks
or trousers, safety work shoes, heavy duty work gloves, hard hat, a safety face shield, or
safety glasses for eye protection and a good grade of ear plugs or other sound barriers for
hearing protection.
Start the unit in a safety place. Open fuel cap slowly to release any pressure which may
have formed in fuel tank. To prevent a fire hazard, move at least10 feet (3 meters) from
fuel area before starting.
Comply with all fire prevention regulations compliance with all local, state, or federal laws
is the user’s responsibility. Replacement spark arrester screen kits are available from
distributor.
POW60481 EN
Copyright © 2014 VARO P a g e | 5 www.varo.com
Do not run engine in ill-ventilated closed space. There is a danger of poisoning by exhaust
gas.
Turn unit off before setting it down. Stop engine while transporting the machine.
Keep handles dry, clean and free of fuel mixture.
Always hold unit firmly with hands, the thumb and fingers encircling the handles.
Keep all screws and fasteners tight. Pay special attention to tightness of the bolt to fix a
cutting head. Never operate your equipment when it is improperly adjusted or not
completely and securely assembled.
Never use non-approved cutting attachment!
Use our genuine spare parts for repairing or replacing worn parts. We are not responsible
for any mechanical troubles caused by using substitute parts.
Keep the cutting head as close to ground as practical. Avoid hitting small objects with the
cutting line. When cutting on a slope, stand below the cutting line.
Always keep balance. NEVER trim on a hill or slope, etc. if there is the slightest chance of
slipping, or losing firm footing.
Check area you will be trimming for debris that may be struck or thrown during operation.
Keep all parts of your body and clothing away from cutting line when starting or running
engine. Before starting engine, make sure the cutting line will not come in contact with any
obstacle.
Stop engine before examining cutting line.
Store equipment away from possible flammable materials, such as gas-powered water
headers, clothes dryers, or oil-fired furnaces, portable heaters, etc.
Always keep the debris shield/guard, cutting line, and engine free of debris build-up. Never
use a grass trimmer without safety devices.
If you use without safety devices, it may injure operator or persons nearby seriously.
Operation of equipment should always be restricted to mature and properly instructed
individuals. Never allow children to operate this unit.
Never operate while being tired, ill or under influence if alcohol or other drugs.
Check that no leakage of fuel tank.
Check to find coating of a high-tension cable and a spark plug is not peeled.
If a part of a body touches a naked cord of high-tension part while engine is running, you
will be struck by electricity.
KICKBACK: a sudden side ways or backward motion of the machine unit,
which may occur when a cutting line jams or catches on an object such as
a tree stump.
5.2 What not to do
Do not use any other fuel that no recommended in your manual. Always follow instructions
in the fuel and lubrication section of this manual. Never use gasoline unless it is properly
mixed with 2-cycle engine lubricant. Permanent damage to engine will result, voiding
manufacturer’s warranty.
DO NOT SMOKE while refuelling and operating equipment.
DO NOT OPERATE UNINT WITHOUT A MUFFLER and properly install muffler shield.
DO NOT TOUCH or let your hands or body come in contact with the muffler .Hold unit with
thumbs and fingers encircling the handles
DO NOT OPERATE UNIT IN AWKWARD POSITIONS, off balance, outstretched arms, or
one-handed. Always use two hands when operating unit with thumbs and fingers
encircling the handles.
DO NOT RAISE STRINGHEAD above ground level while unit is operating injury to
operator could result.
DO NOT USE UNIT FOR ANY PURPOSES OTHER than trimming lawn or garden areas.
POW60481 EN
Copyright © 2014 VARO P a g e | 6 www.varo.com
DO NOT operate unit for prolonged period. Rest periodically.
DO NOT OPERATE UNIT WHILE UNDER THE INFLUENCE OF ALCOHOL OR DRUGS.
DO NOT OPERATE UNIT UNLESS DEBRIS SHIELD AND/OR GUARD IS INSTALLED
AND IN GOOD CONDITION
DO NOT ADD, REMOVE OR ALTER ANY COMPONENTS OF THIS PRODUCT. Doing
so could cause personal injury and/or damage the unit.
DO NOT operate your unit near or around flammable liquids or gases whether in or out of
doors. An explosion and/or fire may result.
5.3 Danger of fire and burn injuries.
Always use extreme care when handling fuel! Fuel is highly flammable.
Never attempt to fuel the line trimmer if the fuel system components are damaged or are
leaking.
Never attempt the refuel the engine while it is running or still warm, allow it to cool before
fuelling.
Never smoke or light any fires near the line trimmer or fuels.
Always transport and store fuels in an approved container.
Never place flammable material close the engine muffler.
Never operate the line trimmer without a properly functioning muffler and spark arrestor
installed.
Never operate the line trimmer unless it is properly assembled and in good working
condition.
Do not use petrol which contains ethanol or methanol as it may damage the fuel lines and
other engine parts.
Mix only enough fuel for your immediate needs. If fuel must be stored longer than 30 days,
it should first be treated with a stabilizer or similar product.
5.4 Observance while operating
Operate alone without assistance. Do not allow anyone to enter within a 15- meter radius
from the operator.
If several grass trimmers are in use simultaneously, keep minimum 15 meter distance
from each operator.
Avoid stones and stumps. This may damage the cutting line. Should you hit something
accidentally, stop engine and check the cutting line for damage.
An operator must have a firm footing when using a grass t. Do not operate during rain.
Be sure that a cutting head is attached firmly in an adequate position.
Do not cut tri close to an edge of a fence, a cliff or such hard objects.
When removing foreign objects wound around a cutting head, a gear case or a guard, be
sure to stop an engine by an ignition switch. While an engine is running, never put your
hands etc. close to a cutting line even if it is not rotating. Your motion may let a throttle
cable pulled to suddenly raise an engine revolution, which may get you hurt by a rotating
cutting line.
POW60481 EN
Copyright © 2014 VARO P a g e | 7 www.varo.com
6 ASSEMBLY
It is necessary to fit the drive shaft the handle safety guard, harness and adjust the handle and
harness.
6.1 Fitting the plastic guard
Slide the plastic guard over the drive shaft as shown in the
picture.
Place plastic guard over drive shaft until metal piece fits in the
guard and you can fit the bolt through the guard and metal
piece. Tighten the bolt.
6.2 Fitting the curvy drive shaft
Put lower part into the shaft of the upper part. Push down the
iron bullet and push forward until the bullet fits into the
restrictor hole. Tighten the screw bolt manually.
6.3 Fitting the handle
6.3.1 If you use the "OPEN" type handle bar, by the following method:
Loosen the handle bar by unscrewing the bolt. Slide the O-shaped handle bar over the drive
shaft. Leave 135 mm between the O-shaped handle and the operating handle. Tighten the
bolt to fix the O-shaped handle.
WARNING! Do not use the line cutting head without the plastic guard.
POW60481 EN
Copyright © 2014 VARO P a g e | 8 www.varo.com
7 BEFORE STARTING WORK
7.1 Fuelling
MOTOR FUEL: mix the petrol and oil at 25:1 ONLY
8 OPERATION
8.1 Starting the Grass Trimmer
1. Set the STOP switch to “|”
2. Set the choke lever to .
3. Press the fuel pump (primer) 6 times.
4. Hold the trimmer firmly. Then tug sharply on
the starter cable 6 times.
POW60481 EN
Copyright © 2014 VARO P a g e | 9 www.varo.com
5. Once the engine has started, move the choke lever to and
allow the trimmer to warm up for approximately 10 seconds.
Turning the engine Off:
Set the STOP switch to “STOP”.
8.2 Stopping the grass trimmer
Warning: The cutting head will continue to rotate for a few seconds after the
engine has stopped.
1. Release the throttle trigger and allow the engine to idle for a few moments.
2. Move the ignition switch to the off position marked STOP.
3. The engine will now stop.
8.3 Running in the engine
1. During the first ten hours of work, run the engine at a moderate RPM.
2. We advise you in any case not to maintain your engine at a high speed as the different
components must settle with each other during the process of running in the engine.
3. It is at the end of the run-in period that the engine will reach its maximum power.
4. After the first two hours of work, stop and make sure that all nuts and screws are securely
fastened, and tighten them if necessary.
8.4 Use of the Grass Trimmer
Cut the grass like you are in a corridor about 1.5m wide. Move step by step, moving the
machine from left to right and vice-versa. Make sure at each step that you are still well
balanced on your feet.
The line trimmer has a bump feed mechanism which releases line without having to stop
the engine. To release additional line lightly tap the cutting line and spool assembly on the
ground while operating the unit at high speed.
NOTE. Always keep the trimming line fully extended. Line release becomes
more difficult as the cutting line becomes shorter.
Each time the head is bumped, it releases approximately 2cm of line. The cut off knife on
the guard will automatically cut off any excess line. For best results tap the head on hard
soil or bare ground.
Do not hit stones (even small ones), piles of earth, and small pieces of wood or anything
else that could be hidden or poorly visible in the grass.
POW60481 EN
Copyright © 2014 VARO P a g e | 10 www.varo.com
If you hit a large object by accident, or if you block the cutting tool due to overloading or
having the cutter jammed with grass, you must stop the engine.
NOTE. All protective devices of the machine as well as protective
equipment must be maintained in good operation condition during the
period of use.
9 CLEANING AND MAINTENANCE
9.1 Air filter
Accumulated dust in the air filter will reduce engine efficiency. Increase fuel consumption and
allow abrasive particles to pass into the engine. Remove the air filter as often as necessary to
maintain a clean condition.
Remove filter cover by pressing in the sides and lifting it off.
Light surface dust can readily be removed by tapping the filter.
Heavy deposits should be washed out in suitable solvent.
9.2 Fuel filter
Fuel tank is fitted with a filter.
Filter is situated at the free end of fuel pipe and can be picked
out through fuel port with a piece of hooked wire or the like.
Check the fuel filter periodically. Do not allow dust to enter the
fuel tank. Clogged filter will cause difficulty when starting
engine or abnormalities in engine performance.
When the filter is dirty, replace the filter.
When the inside of the fuel tank is dirty, it can be cleaned by
rinsing the tank out with petrol.
9.3 Checking the Spark Plug
Check the spark plug every 10-15 hours of use.
1. Remove the spark plug cover.
2. Use the spark plug wrench to remove the spark plug, by
turning it counter-clockwise.
3. Clean and adjust the spark plug gap to 0.6 - 0.7mm.
4. Replace any damaged or visibly worn plug with a TORCH
L8RTC or equivalent spark plug.
5. Install the spark plug finger tight in the cylinder head, then
tighten it firmly with the spark plug wrench.
9.4 Storage and maintenance after use
When you finish working, clean the petrol grass trimmer completely, making sure there is
no grass or dirt wrapped in the cutting tools.
Be aware to not hit or cut the fuel tank if you put it onto the ground. Do not let the petrol
grass trimmer fall down to the floor or it may damage the machine.
Store the petrol grass trimmer away from direct sunlight.
Do not store in a nylon bag as this can encourage the formation of mould.
POW60481 EN
Copyright © 2014 VARO P a g e | 11 www.varo.com
At the end of the season, give the petrol grass trimmean overall cleaning and a thorough
check.
Do not leave the petrol grass trimmer resting on the floor for extended periods as it could
cause the shape of the guard to alter, posing a safety risk. Hang it off the floor by the top
handgrip.
Whenever the machine is not used for a long period of time, proceed as follows:
Empty the fuel tank completely.
Protect all metal engine parts from corrosion by coating them with oil.
Remove the spark plug, put a few drops of oil into the cylinder and then pull the recoil
starter 2 to 3 times in order to distribute the oil evenly. Replace the spark plug.
10 TROUBLESHOOTING
10.1 Power loss or sudden stopping of the engine
Check whether the fuel tank is empty.
The mixture does not reach the carburettor. Clean the fuel filter in the fuel tank.
There is water in the mixture. Drain and rinse all the fuel system with fuel.
The air filter is dirty. Clean the air filter.
There are carbon deposits in the cylinder exhaust pipe or the muffler. Clean those or
change the muffler.
10.2 Bad quality cut
Overloaded cutting due to too high grass or too thick for engine power.
Wrapped vegetal material on the cutting tool.
11 TECHNICAL DATA
model
POW60481
Engine
WL1E36F
Cylinder content:
29.7 ccm
Power:
1.0 kW
Tank content:
600 ml
Mowing width threading head:
420 mm
Wire diameter:
2.0 mm
max. engine revolutions
7500 min-1.
max. Revolutions cutting install.
7500 min-1
Spark plug
TORCH L8RTC
Weight
5.6 kg
12 NOISE
Noise emission values measured according to relevant standard. (K=3)
Acoustic pressure level LpA
91 dB(A)
Acoustic power level LwA
114 dB(A)
ATTENTION! Wear hearing protection when sound pressure is over 85
dB(A).
aw (Vibration):
Max 5.0m/s²
K = 1.5 m/s²
13 WARRANTY
This product is warranted as provided by law for a 24 months period effective from the
date of purchase by the first user.
POW60481 EN
Copyright © 2014 VARO P a g e | 12 www.varo.com
This warranty covers all material or production flaws excluding : batteries, chargers,
defective parts subject to normal wear & tear such as bearings, brushes, cables, and
plugs, or accessories such as drills, drill bits, saw blades, etc. ; damage or defects
resulting from maltreatment, accidents or alterations; nor the cost of transportation.
Damage and/or defects resulting from inappropriate use also do not fall under the
warranty provisions.
We also disclaim all liability for any bodily injury resulting from inappropriate use of the
tool.
Repairs may only be carried out by an authorised customer service centre for Powerplus
tools.
You can always obtain more information at the number 00 32 3 292 92 90.
Any transportation costs shall always be borne by the customer, unless agreed otherwise
in writing.
At the same time, no claim can be made on the warranty if the damage of the device is the
result of negligent maintenance or overload.
Definitely excluded from the warranty is damage resulting from fluid permeation, excessive
dust penetration, intentional damage (on purpose or by gross carelessness), inappropriate
usage (use for purposes for which the device is not suitable), incompetent usage (e.g. not
following the instructions given in the manual), inexpert assembly, lightning strike,
erroneus net voltage. This list is not exhaustive.
Acceptance of claims under warranty can never lead to the prolongation of the warranty
period nor commencement of a new warranty period in case of a device replacement.
Devices or parts which are replaced under the warranty therefore remain the property of
Varo NV.
We reserve the right to reject a claim whenever the purchase cannot be verified or when it
is clear that the product has not been properly maintained. (Clean ventilation slots, carbon
brushes serviced regularly, etc.).
Your purchase receipt must be kept as proof of date of purchase.
Your appliance must be returned undismantled to your dealer in an acceptably clean state,
(in its original blow-moulded case if applicable to the unit), accompanied by proof of
purchase.
14 ENVIRONMENT
Should your appliance need replacement after extended use, do not discard it
with the household rubbish but dispose of it in an environmentally safe way.
Please dispose of used motor oil in a manner that is compatible with the
environment. We suggest you take it in a sealed container to your local service
station for reclamation. Do not throw it in the trash or pour it on the ground.
POW60481 EN
Copyright © 2014 VARO P a g e | 13 www.varo.com
15 DECLARATION OF CONFORMITY
VARO N.V. - Joseph Van Instraat 9 - BE2500 Lier - BELGIUM, declares that,
Product : Grass trimmer 29.7cc
Trade mark: POWERplus
Model : POW60481
is in conformity with the essential requirements and other relevant provisions of the applicable
European Directives, based on the application of European harmonized standards. Any
unauthorized modification of the apparatus voids this declaration.
European Directives (including, if applicable, their amendments up to the date of signature);
2004/108/EC
2006/42/EC
2000/14/EC Annex V LwA 110dB(A) / 114dB(A)
97/68/EC Engine Class SH2 G4
EDP 50h
Testing Authority VCA / Bristol
European harmonized standards (including, if applicable, their amendments up to the date of
signature);
EN ISO 11806-1 : 2011
EN ISO 14982 : 2009
Keeper of the Technical Documentation : Philippe Vankerkhove, VARO Vic. Van Rompuy
N.V.
The undersigned acts on behalf of the company CEO,
Philippe Vankerkhove
Regulatory Affairs Compliance Manager
07/08/13
1

Hulp nodig? Stel uw vraag in het forum

Spelregels
1

Forum

Powerplus-POW60481

Misbruik melden

Gebruikershandleiding.com neemt misbruik van zijn services uitermate serieus. U kunt hieronder aangeven waarom deze vraag ongepast is. Wij controleren de vraag en zonodig wordt deze verwijderd.

Product:

Bijvoorbeeld antisemitische inhoud, racistische inhoud, of materiaal dat gewelddadige fysieke handelingen tot gevolg kan hebben.

Bijvoorbeeld een creditcardnummer, een persoonlijk identificatienummer, of een geheim adres. E-mailadressen en volledige namen worden niet als privégegevens beschouwd.

Spelregels forum

Om tot zinvolle vragen te komen hanteren wij de volgende spelregels:

Belangrijk! Als er een antwoord wordt gegeven op uw vraag, dan is het voor de gever van het antwoord nuttig om te weten als u er wel (of niet) mee geholpen bent! Wij vragen u dus ook te reageren op een antwoord.

Belangrijk! Antwoorden worden ook per e-mail naar abonnees gestuurd. Laat uw emailadres achter op deze site, zodat u op de hoogte blijft. U krijgt dan ook andere vragen en antwoorden te zien.

Abonneren

Abonneer u voor het ontvangen van emails voor uw Powerplus POW60481 bij:


U ontvangt een email met instructies om u voor één of beide opties in te schrijven.


Ontvang uw handleiding per email

Vul uw emailadres in en ontvang de handleiding van Powerplus POW60481 in de taal/talen: Engels als bijlage per email.

De handleiding is 0,5 mb groot.

 

U ontvangt de handleiding per email binnen enkele minuten. Als u geen email heeft ontvangen, dan heeft u waarschijnlijk een verkeerd emailadres ingevuld of is uw mailbox te vol. Daarnaast kan het zijn dat uw internetprovider een maximum heeft aan de grootte per email. Omdat hier een handleiding wordt meegestuurd, kan het voorkomen dat de email groter is dan toegestaan bij uw provider.

Stel vragen via chat aan uw handleiding

Stel uw vraag over deze PDF

Andere handleiding(en) van Powerplus POW60481

Powerplus POW60481 Gebruiksaanwijzing - Nederlands - 14 pagina's

Powerplus POW60481 Gebruiksaanwijzing - Deutsch - 14 pagina's

Powerplus POW60481 Gebruiksaanwijzing - Français - 14 pagina's


Uw handleiding is per email verstuurd. Controleer uw email

Als u niet binnen een kwartier uw email met handleiding ontvangen heeft, kan het zijn dat u een verkeerd emailadres heeft ingevuld of dat uw emailprovider een maximum grootte per email heeft ingesteld die kleiner is dan de grootte van de handleiding.

Er is een email naar u verstuurd om uw inschrijving definitief te maken.

Controleer uw email en volg de aanwijzingen op om uw inschrijving definitief te maken

U heeft geen emailadres opgegeven

Als u de handleiding per email wilt ontvangen, vul dan een geldig emailadres in.

Uw vraag is op deze pagina toegevoegd

Wilt u een email ontvangen bij een antwoord en/of nieuwe vragen? Vul dan hier uw emailadres in.



Info