771227
44
Verklein
Vergroot
Pagina terug
1/54
Pagina verder
WaterMaster 25 - 35 - 45 - 70 - 85 - 120 : A1006482 - 664Y7300 • D
en
42
EN
FR
NL
ES
IT
DE
PL
RU
STARTING UP
STARTING UP THE WATER HEATER
Set-up conditions
All connections made
Gas conversion carried out as required
Condensate trap full of water
Electrical power supply on
Gas supply open
Hydraulic circuit(s) full of water
Procedure
1. Check that there is no gas leak.
2. Push in the ON/OFF master switch ( ).
3. Check the gas pressure and allow the appliance to heat up for a few minutes
4. Check and adjust the burner according to local standards and regulations, refer to “Checking and
Adjusting the Burner” on page 42.
5. Set the Domestic Hot Water temperature to the required value using the control panel. Refer to
“Water heater Setup Guide on page 8 and to the Installers Handbook.
6. After 5 minutes of operation, check that the pressure is at 1.5 bar.
7. If required, top it up with water to get the required pressure.
Follow-on tasks
1. Close the primary circuit lling valve and disconnect the lling connection as required.
2. Check that there are no leaks.
3. Check that the ow rate in the appliance is sucient as follows :
Operate the appliance at maximum power
Once the temperatures are stable, read out the supply and return temperatures
Check that the dierence between the supply and return temperature is equal or less than 20k.
If the Delta T is higher than 20k, check the pump settings/specications.
CHECKING AND ADJUSTING THE BURNER
When the burner operates at full power, the CO2 rate must be within the limits mentioned in
the technical characteristics, (see “Combustion characteristics” on page 17).
Set-up conditions
Operating water heater
Procedure
1. Check if the ACVMAX parameters are set to meet the user's requirements (refer to Water heater
Setup Guide” on page 8), and change them if required.
2. Put the appliance to maximum power mode (Refer to the Installers Handbook).
3. Using a pressure tester, check that the dynamic gas pressure at the gas valve is at least 18 mbar.
4. Allow the appliance to heat for a few minutes until it reaches at least 60°C.
5. Measure the burner combustion by placing the flue gas analyzer probe in the measurement unit
port on the flue pipe and compare the CO and CO2 values displayed with those indicated in the
combustion characteristics table.
6. If the CO2 value differs by more than 0.3%, carry out the adjustment mentioned in the procedure
below.
7. Then put the appliance to the minimum power mode (Refer to the Installer's Handbook provided
with the appliance). Allow the appliance to stabilize for a few minutes.
8. Measure the CO2 level. It must be equal to the value at full power, or lower than that value by 0.5%
maximum. If there is a significant deviation, please contact ACV's maintenance department.
CO2 adjustment procedure
To adjust the CO2 rate, rotate the throttle screw (1) :
to the left (counterclockwise) to increase the CO2. rate.
to the right (clockwise) to decrease the CO2. rate.
The CO2 adjustment screw (1) of the WM 120 is a worm screw, whose rotation in a direction
causes the CO2 rate to cyclically increase to the maximum, then decrease to the minimum, then
increase again, and so on. To adjust, monitor the value change on the analyzer to determine
whether the rotation in the selected direction causes the CO2 value to increase or decrease.
Follow-on tasks
None
1
WaterMaster® 25 - 35 - 45 - 70 - 85 WaterMaster® 120
44

Hulp nodig? Stel uw vraag in het forum

Spelregels
1

Forum

ACV-Watermaster

Zoeken resetten

Misbruik melden

Gebruikershandleiding.com neemt misbruik van zijn services uitermate serieus. U kunt hieronder aangeven waarom deze vraag ongepast is. Wij controleren de vraag en zonodig wordt deze verwijderd.

Product:

Bijvoorbeeld antisemitische inhoud, racistische inhoud, of materiaal dat gewelddadige fysieke handelingen tot gevolg kan hebben.

Bijvoorbeeld een creditcardnummer, een persoonlijk identificatienummer, of een geheim adres. E-mailadressen en volledige namen worden niet als privégegevens beschouwd.

Spelregels forum

Om tot zinvolle vragen te komen hanteren wij de volgende spelregels:

Belangrijk! Als er een antwoord wordt gegeven op uw vraag, dan is het voor de gever van het antwoord nuttig om te weten als u er wel (of niet) mee geholpen bent! Wij vragen u dus ook te reageren op een antwoord.

Belangrijk! Antwoorden worden ook per e-mail naar abonnees gestuurd. Laat uw emailadres achter op deze site, zodat u op de hoogte blijft. U krijgt dan ook andere vragen en antwoorden te zien.

Abonneren

Abonneer u voor het ontvangen van emails voor uw ACV Watermaster bij:


U ontvangt een email met instructies om u voor één of beide opties in te schrijven.


Ontvang uw handleiding per email

Vul uw emailadres in en ontvang de handleiding van ACV Watermaster in de taal/talen: Engels als bijlage per email.

De handleiding is 7.49 mb groot.

 

U ontvangt de handleiding per email binnen enkele minuten. Als u geen email heeft ontvangen, dan heeft u waarschijnlijk een verkeerd emailadres ingevuld of is uw mailbox te vol. Daarnaast kan het zijn dat uw internetprovider een maximum heeft aan de grootte per email. Omdat hier een handleiding wordt meegestuurd, kan het voorkomen dat de email groter is dan toegestaan bij uw provider.

Stel vragen via chat aan uw handleiding

Stel uw vraag over deze PDF

loading

Andere handleiding(en) van ACV Watermaster

ACV Watermaster Gebruiksaanwijzing en installatiehandleiding - Nederlands - 52 pagina's

ACV Watermaster Gebruiksaanwijzing en installatiehandleiding - Deutsch - 48 pagina's


Uw handleiding is per email verstuurd. Controleer uw email

Als u niet binnen een kwartier uw email met handleiding ontvangen heeft, kan het zijn dat u een verkeerd emailadres heeft ingevuld of dat uw emailprovider een maximum grootte per email heeft ingesteld die kleiner is dan de grootte van de handleiding.

Er is een email naar u verstuurd om uw inschrijving definitief te maken.

Controleer uw email en volg de aanwijzingen op om uw inschrijving definitief te maken

U heeft geen emailadres opgegeven

Als u de handleiding per email wilt ontvangen, vul dan een geldig emailadres in.

Uw vraag is op deze pagina toegevoegd

Wilt u een email ontvangen bij een antwoord en/of nieuwe vragen? Vul dan hier uw emailadres in.



Info